德國陽光蓄電池結構于日常保養
發布時間：2016-05-30 15:47:05 瀏覽次數：
德國陽光蓄電池膠體鉛酸蓄電池的基本結構與日常必要采取檢查及維護。
The basic structure of the German sunshine battery colloid lead acid battery and the daily necessity to take inspection and maintenance.
膠體鉛酸德國陽光蓄電池是對液態電解質的普通鉛酸蓄電池的改進，用膠體電解液代換了硫酸電解液，在安全性、蓄電量、放電性能和使用壽命等方面較普通電池有所改善。膠體鉛酸蓄電池采用凝膠狀電解質，內部無游離液體存在，在同等體積下電解質容量大，熱容量大，熱消散能力強，能避免一般蓄電池易產生熱失控現象；電解質濃度低，對極板的腐蝕作用弱；濃度均勻，在存在電解液分層現象。
Colloidal lead-acid sunshine German batteries is improvement of ordinary lead-acid batteries of the liquid electrolyte, colloid electrolyte substitution sulphate electrolyte, in safety, storage, discharge performance and service life than ordinary batteries improved. Colloidal lead-acid battery with gelled electrolyte, there is no free liquid, under the same volume electrolyte capacity big, heat capacity, heat dissipation ability, avoid batteries generally prone to thermal runaway phenomenon; low electrolyte concentration, weak corrosion effect on the plate; uniform concentration, in the presence of electrolyte stratification phenomenon.
膠體鉛酸蓄電池的性能優于閥控密封鉛酸德國陽光蓄電池，膠體鉛酸蓄電池具有使用性能穩定，可靠性高，使用壽命長，對環境溫度的適應能力（高、低溫）強，承受長時間放電能力、循環放電能力、深度放電及大電流放電能力強，有過充電及過放電自我保護等優點。
Colloidal lead-acid battery performance is superior to the valve controlled sealed lead-acid sunshine German batteries, colloidal lead-acid battery has stable use performance, high reliability using long life, to the environment temperature adaptation ability (high and low), and under long time discharge capacity, circulation discharge capacity, depth of discharge and large current discharge ability strong, charge or discharge self protection and other advantages.
目前用于電動自行車的國產膠體鉛酸蓄電池是在AGM隔板中通過真空灌注，把硅膠和硫酸溶液灌到蓄電池正、負極板之間。膠體鉛酸蓄電池在使用初期無法進行氧循環，這是因?yàn)槟z體把正、負極板都包圍起來了，正極板上面產生的氧氣無法擴散到負極板，無法實現與負極板上的活性物質鉛還原，只能由排氣閥排出，與富液式蓄電池一致。
At present, the domestic lead-acid battery used for electric bicycle is in the AGM partition plate through the vacuum infusion, the silica gel and sulfuric acid solution to the battery positive and negative plates. Colloidal lead-acid batteries in the initial stage of using oxygen cycle. This is because colloid to the positive and negative plates are surrounded, produce positive plate above the oxygen cannot be spread to negative plate, can not be achieved with the negative plate active material of lead reduction, only is discharged through the exhaust valve, and rich liquid type battery.
膠體鉛酸蓄電池使用一段時間后膠體開始干裂和收縮，產生裂縫，氧氣通過裂縫直接到負極板進行氧循環。排氣閥就不再經常開啟，膠體鉛酸蓄電池接近于密封工作，失水很少。所以針對電動自行車蓄電池主要失效是失水機理，采用膠體鉛酸蓄電池可獲得非常好的效果。膠體電解質是通過在電解液中加入凝膠劑將硫酸電解液凝固成膠狀物質，通常膠體電解液中還加有膠體穩定劑和增容劑，有些膠體配方中還加有延緩膠體凝固和延緩劑，以便于膠體加注。 信息請登陸:輸配電設備網
Colloidal lead-acid batteries used for a period of time colloid starts cracking and shrinkage, cracks, oxygen through the cracks directly to the negative plate oxygen cycle. Exhaust valve is no longer always open, the colloid lead-acid battery is close to the work of sealing, little water loss. Therefore, the main failure of the electric bicycle battery is the loss of water mechanism, the use of colloidal lead-acid batteries can be a very good effect. Colloidal electrolyte is by gel agent is added in the electrolyte in the solidification of electrolyte of sulfuric acid into a jelly like substance, usually of gel electrolyte are also added in colloid stabilizers and compatibilizer, some gel formula are also added delay the coagulation of colloids and retardant, in order to facilitate the colloid filling. Information please visit: transmission and distribution equipment network
過去，閥控式鉛酸蓄電維護起來比較麻煩，因?yàn)樾铍姵卦谑褂玫臅r(shí)候要分解電解液中的水，所以要定期檢測電解液的比重，蓄電池的電壓等參數，消耗的電解液，要定期加水來補充，而后又有德國陽光蓄電池出現，主要以德國陽光蓄電池（為主，由于不需加水，所以德國陽光蓄電池從一開始便被稱為免維護電池，而生產廠家又承諾該電池的使用壽命為10 ~ 20年（最少為8年）。
Past, valve controlled lead-acid battery maintenance up more trouble, because the battery in use to water in the electrolyte decomposition, so the proportion of regular testing electrolyte, battery voltage and other parameters, the consumption of the electrolyte to the water regularly to supplement, then there are the sun battery, mainly to sunshine German batteries (mainly, because they do not need to add water, so sunshine German batteries from began is said to be maintenance free batteries, while the manufacturers commitment to the service life of the battery is 10 ~ 20 years (minimum 8 years).
首先明確表明德國陽光蓄電池是膠體免維護蓄電池，不是敞口式鉛酸蓄電池更不是少維護型閥控型密封鉛酸蓄電池。
The first clear show that the German solar battery is a gel maintenance free battery, not an open type lead-acid battery is not less maintenance type valve controlled sealed lead-acid batteries.
對于膠體蓄電池的維護：正常運行狀態下，每隔三個月應該進行一次充放電，第一是對電池容量的一種補充，第二是作為對電池活性物質的激活。
For the maintenance of the colloid storage battery: under normal operation condition, the charge discharge should be carried out once every three months. The first is a supplement to the capacity of the battery, and the second is the activation of the active material of the battery.
德國陽光蓄電池日常檢查項目：端電壓，連接處有無松動、腐蝕現象。電池殼體有無滲漏和變形。極柱、安全閥周圍是否有酸霧液逸出。如具備專業的蓄電池監控系統，應通過監控系統對電池組的總電壓、電流、標示電池的單體電壓、溫度進行監控，并定期自動對蓄電池組進行放電容量測試。實時了解電池充放電曲線及性能，發現故障及時處理。每一個單體電池極柱（板）的接觸表面。
Germany sunshine battery daily inspection project: the terminal voltage, the connection is loose, corrosion phenomenon. Leakage and deformation of the battery shell. The pole and the safety valve around whether liquid mist escaping. With professional battery monitoring system, by monitoring system to monitor the battery voltage, current, mark battery monomer voltage, temperature, and regular automatic on the battery to discharge capacity test. Real time understanding of the battery charging and discharging curve and performance, and timely processing of the fault. Contact surface of each single cell pole (plate).
這樣就給國內的技術和維護人員一種誤解，似乎這種電池既耐用又完全不需要維護，許多用戶從裝上電池后就基本沒有進行過維護和管理；因而在90年代初國內使用的電池出現了很多以前未遇到的新問題，例如，電池殼變形、電解液滲漏、容量不足、電池端電壓不均勻等；這些現象不單在國內，就是在比我國早采用電池的國外也同樣存在。
This to the domestic technical and maintenance personnel a misunderstanding seems to this battery is both durable and completely without the need for maintenance, many users from installed after the battery is basically no maintenance and management; thus in the early 1990s domestic battery appeared many new problems that were not previously encountered, for example, battery shell deformation, electrolyte leakage, lack of capacity, the battery terminal voltage uneven; these phenomena not single in the country, is in than the early adoption of a foreign battery also exist.
歡迎了解德國陽光蓄電池我們是集銷售、安裝、維修服務于一體的公司，以高效率的工作方式及良好的商業道德認真對待每一位客戶，真正讓每一位客戶無任何后顧之憂。
Welcome to learn German sun battery we are set sales, installation, maintenance services in one of the company, with high efficiency and good business ethics seriously each and every customer and really let every customer without any worries.
The company will provide you with the most detailed technical guidance in Germany, the sun battery and the most perfect after-sales service. Welcome to call us!
聯系我們
86-010-57149028
chinaexide@163.com
